為什麼我的柚木餐桌有裂口?


2

我的餐桌有裂痕,最近我是posted a question詢問如何修理它。我收到了許多建議,以發布有關桌子構造的詳細信息,尤其是頂部如何連接到下面的框架。目的是要審查如何防止將來出現進一步的裂縫。

以下是許多照片。據我所知,構造的方式允許適度的擴張/收縮。但是,請讓我知道有關該結構的任何內容是否易於破解。

leg support

cross beams

expansion joint

assembly

area under main table top crack

7

The top is attached (at least in part) using buttons, although it's hard to tell what's going on with the cross-bracing framework. Buttons are one of the established ways of allowing for seasonal changes in the width of a tabletop. These ones are crude though, and as a result may not allow sufficient movement. The ones on the sides in particular must allow for the button to move into and out of their respective slots far enough to account for half of the total movement.

Pictures 3 and 5 seem to show that the buttons could be the cause. In no. 3 the shoulder of the button is hard up against the apron, and in the fifth image it looks like the tongue of the button is a very tight fit in its slot.

The joints are part of the problem
The fact that the tabletop had glue-line failures is another piece of evidence. It indicates that the glued joints are weaker than they should be.

If the glued joints are done properly when there is a movement issue while the tabletop might still split the cracks will completely ignore the joints, because well-made glued joints are literally stronger than the wood around them.

The glue itself or the glueing technique used may be at fault here. Teak is a tropical wood and like many tropical woods it has a certain natural oily/resinous nature which means it can be tricky to glue well. Solvent-cleaning of joint surfaces just prior to glueing is a common recommendation when working with such woods.


2

You are going to need to find someone that can take this apart and re-glue it.
The last photo shows what appear to be water spots around the glue joint. It looks to me like some quantity of water was introduced to the top of the table and it soaked into the joint causing the wood to expand. Then, when it dried, the glue joint pulled apart because it had been weakened by exposure to water.